[Healeys] FW: Squealy Brakes

Tom Felts Tomfelts at windstream.net
Tue Apr 16 04:09:11 MDT 2024


I found that if I applied some Al antiseize grease on the back of the metal that the pads are attached to, this stops the squeal 


From: "Simon Lachlan via Healeys" <healeys at autox.team.net> 
To: "Healeys" <healeys at autox.team.net> 
Sent: Tuesday, April 16, 2024 4:43:25 AM 
Subject: [Healeys] FW: Squealy Brakes 







I have a BT7 also. (MkII). I had squeaky brakes and found my anti-shim pads to be pretty useless. Worse, in a way, sometimes the brakes were quiet and sometimes they really howled! 

Anyhow…..I asked around and did some research which led me to EBC pads. I think there are two or three materials used…..depending on what you use the car for. “Greenstuff” is the regular road set and the ones that I use. 

According to my files(!), the code was DP2141 ie for Girling 14s. (I’ve switched to 16s which take DP2291.) 

And, with particular regard to anti-shim pads, EBC supply a rubber backing material which you cut to size yourself. Back to the files:- They describe the material as a " High performance 200MP pressure sensitive 

acrylic adhesive on 58 lb polycoated kraft paper liner. High temperature formulation, solvent resistance, shear adhesion and HSE, low LSE. Use for general industrial joining. 5.0 mil thick with 4.0 mil 

liner.") The instructions say:- "Cut with scissors to shape required and apply these shims to the reverse side (painted side) of the brake pads to prevent brake noise. The fibre must cover all areas contacted 

by the hydraulic pistons or the calliper supports". 

I see that I’ve been using EBC pads since some years before April 2012. They work for me. 

I’ve attached their installation instructions which are pretty generic…nothing much unique to their pads. 

Simon 








From: Healeys < [ mailto:healeys-bounces at autox.team.net | healeys-bounces at autox.team.net ] > On Behalf Of m.g.sharp--- via Healeys 
Sent: Tuesday, April 16, 2024 1:26 AM 
To: Healey List < [ mailto:healeys at autox.team.net | healeys at autox.team.net ] > 
Subject: [Healeys] Squealy Brakes 




Hi all, I have had intermittent squealy brakes on my BT7 the last year or so. I got it out of hibernation a week ago and the squealing is worse, it seems. I don’t mind heads turning when I pull up at a light, but not because it sounds like I just ran over a cat. 



I put new pads in a few years back and installed the anti-squeal shims, but they did not work. Today I pulled out the pads, tossed the shims and lightly rubbed the pads on a sheet of #120 emery on a plate of glass, just to take the sheen of the friction side and ensure the backs were flat. I took a file and gently broke the leading and trailing edges of the friction material, as the edges were quite sharp and though one could be catching. I then cleaned the pads with brake part cleaner. I also lightly used emery on the disks to remove any glaze. I had gone to my local auto parts supplier to see if they had any anti-squeal shims but they don’t sell them separately from the pads. However, they highly recommended a Permatex product with the promising name “Disc Brake Quiet” [sic]. This I applied per the instructions, spraying it on the back of the pads. I blew the dust out of the calipers and, as best I could, checked the pistons for irregularities where they bear on the pads. The calipers were re-built about 5 years ago with stainless pistons and they looked as new. Retaining pins were cleaned and very lightly greased. I re-assembled everything and went out for a test drive. 



The results were staggering in that there was no difference whatsoever. 



So folks – any good ideas out there? I am wondering if should switch out the pads, but mine are barely worn and I am not sure I have record of what I put in, so may end up with the same make. Other than that, I am flummoxed. 



All suggestions welcome. 

_______________________________________________ 
Support Team.Net http://www.team.net/donate.html 
Suggested annual donation $12.75 

Archive: http://www.team.net/pipermail/healeys http://autox.team.net/archive/healeys 

Healeys at autox.team.net 
http://autox.team.net/mailman/listinfo/healeys 

Unsubscribe/Manage: http://autox.team.net/mailman/options/healeys/tomfelts@windstream.net 
-------------- next part --------------
An HTML attachment was scrubbed...
URL: <http://autox.team.net/pipermail/healeys/attachments/20240416/4158dce1/attachment.htm>


More information about the Healeys mailing list