[Healeys] BJ8 Brakes
Oudesluys
coudesluijs at chello.nl
Sat Jul 2 15:51:46 MDT 2016
Use Eesybleed on MC or vacuum pump at bleed nippels.
Kees Oudesluijs
Op 2-7-2016 om 20:48 schreef Roger Grace:
>
> At my wits end with this problem ...
>
> The brakes on my BJ8 have always been hard and bit well with little
> pedal movement.
>
> Changed out the front callipers (to 4 pot) and the problems started.
>
> After repeated bleeding on first push,pedal went to the floor.
>
> After 2/3 pumps the pedal came right up and held.After about 30 secs
> of no pressure on pedal goes to the floor again.
>
> Pistons are all in contact with pads and pads with disc; all looks
> good at callipers.
>
> Suspecting a faulty MC changed it out.
>
> Primed the new MC with fluid prior to installing.
>
> Same story after another 1.5 pints of DOT 4 fluid focusing mainly on
> bleeding front callipers and booster (new); also bled rear drums.
>
> Pedal still goes to the floor on first pump and comes up after pumping
> as before.
>
> No visible leaks and inlet from reservoir shows no leaks: tapped
> callipers with mallet to dislodge any air pockets.
>
> I am using the one man bleed system a with clear tube into a container
> and close the bleeder valve with no visible air at nipple and full
> tube of fluid to container. BTW also changed clutch MC at same time
> and no problems with bleeding etc.
>
> Have now run about 1.5 pints of fluid through the new MC - perhaps am
> being too impatient ?
>
> But no evidence of any air after about 0.5 pint. Typically how much
> fluid is required to clear air from MC and lines ?
>
> Now sort or suspecting the inlet to MC from reservoir but for life of
> me cannot see how air can get in with no visible fluid leaks,
>
> Any ideas from the more AH experienced listers appreciated.
>
> rg
>
>
>
> _______________________________________________
> Support Team.Net http://www.team.net/donate.html
> Suggested annual donation $12.75
> Archive: http://www.team.net/archive
> Forums: http://www.team.net/forums
>
> Healeys at autox.team.net
> http://autox.team.net/mailman/listinfo/healeys
>
> Unsubscribe/Manage: http://autox.team.net/mailman/options/healeys/coudesluijs@chello.nl
>
-------------- next part --------------
An HTML attachment was scrubbed...
URL: <http://autox.team.net/pipermail/healeys/attachments/20160702/52fdc5e8/attachment.html>
More information about the Healeys
mailing list