[Healeys] Steering question

Wed Dec 30 06:47:31 MST 2015

Hi Steve and others…

You can find syringe/injectors in the animal care products at your local Tractor Supply.  They have several sizes including the one you show without nozzles or needles.  Also, at West Marine in the West Epoxy department they have the same Syringes including a long thin nozzle.  Also, they have a larger model with long nozzle for injecting epoxy into voids which could handle larger volumes of oil, grease etc.

Regards,

Bob Begani

From: Healeys [mailto:healeys-bounces at autox.team.net] On Behalf Of BJ8Healeys
Sent: Tuesday, December 29, 2015 11:41 AM
To: 'Ahealey help' <healeys at autox.team.net>
Subject: Re: [Healeys] Steering question

I have used Penrite for many years now after a leak developed in my steering box while using 90W oil.  The Penrite stopped the leak and it has not re-occurred since.

Before adding Penrite to the 'box, I warm the container with a hair dryer.  I have a large (about 3/4" diameter) plastic hypodermic/syringe tool that makes it much easier to fill or top up the 'box without getting the stuff all over the place.  No idea where this tool came from, but I know I didn't buy it.  

Steve Byers

HBJ8L/36666

BJ8 Registry

AHCA Delegate at Large

Havelock, NC USA

From: Healeys [mailto:healeys-bounces at autox.team.net] On Behalf Of Bruce Steele
Sent: Tuesday, December 29, 2015 11:18 AM
To: 'i erbs'; 'Michael Oritt'
Cc: 'Ahealey help'
Subject: Re: [Healeys] Steering question

And pumping in the Penright can be a challenge.  I had the tube come adrift under pressure and blew the thick oil all over the surrounding area.  May hours and several boxes of Q-Tips later I was still finding little globs of the stuff.

Bruce Steele

Brea, CA

1960 BN7

From: Healeys [mailto:healeys-bounces at autox.team.net] On Behalf Of i erbs
Sent: Monday, December 28, 2015 12:31 PM
To: Michael Oritt <michael.oritt at gmail.com <mailto:michael.oritt at gmail.com> >
Cc: Ahealey help <healeys at autox.team.net <mailto:healeys at autox.team.net> >
Subject: Re: [Healeys] Steering question

I switched to Penright oil to stop it from leaking and it really improved the steering response too. You need to pump it as it is very thick and will not pour.

Mr. Ira Erbs
Portland,OR

On Dec 28, 2015 12:19 PM, "Michael Oritt" <michael.oritt at gmail.com <mailto:michael.oritt at gmail.com> > wrote:

All--

Thanks for the good suggestions.  After reading Joseph's I did a quick check on the shocks and found I could tighten the upper shock mounts about one flat (I have Putske's Bilstein shocks mounted) but to be on the safe side I will give the entire front end a good nut and bolt before ruling anything out.

I am running about 27 psi on the Michelin XAS's and I will also check toe as per Dave Porter's suggestion.

In the meantime it has been quite a while since I have checked the fluid level in the steering box and I ran out of time to check it today as  I must move the cold air hose in order to get to it.  What is the preferred lubricant for a box that has not shown any signs of leakage?

Best--Michael Oritt  

On Mon, Dec 28, 2015 at 2:52 PM, David Porter <frogeye at porterscustom.com <mailto:frogeye at porterscustom.com> > wrote:

Wander is generally an issue with the toe-in/out. Check the tie toe ends for excessive wear..
happy new year from Snippy..

On 12/28/2015 12:23 PM, Michael Oritt wrote:

I have a December, 1954 100.  

My wife and I went out for an extended ride yesterday. She drove first and though she does not have much experience with the car she is a quick study and good thinker. After she had driven for perhaps 20 miles she commented that the steering seemed go be "wandering" and required constant small adjustments to keep the car going straight. She felt that the condition did not start until after we had been driving for a while. I did not say anything and thought to myself that she simply was not used to the car. 

After about 50 miles we switched and--whether or not it was because of her comment--I noticed that the car did in fact want to wander and I had to stay on top of keeping the car from veering ever so slightly from left or right of center. The situation remained the same for the balance of the trip--about 150 or so miles in all till we came home.

Whether or not this is relevant--once the wheel is turned to set up for a turn everything seems fine and the car holds a steady track through the turn. It was only when the wheels were straight ahead that the issue presented.

I decided to address this today and with the car in the garage I find that there is virtually no play whatsoever in the steering--perhaps 1/2" or less--whether the front wheels are on or off the ground.  

The "adjustment" procedure described in the manual for "later" 100's simply tells me to loosen the lock nut, remove the cover plate and tighten down the adjusting screw to remove play.  I am not finding a lot of play--again 1/2" or less-whether the car is on the ground or in the air--except when we are rolling.

I have, btw, checked for loose front wheel bearings by trying to wiggle the front wheels both from side to side and back and forth and everything feels just right.  Also I have observed the steering linkage from underneath and when I push the wheels from lock to lock I see no looseness, etc. in the end ball joints or the steering tie rods.

 Suggestions will be appreciated....

Best--Michael Oritt

_______________________________________________
Support Team.Net http://www.team.net/donate.html
Suggested annual donation  $12.75
Archive: http://www.team.net/archive
Forums: http://www.team.net/forums

Healeys at autox.team.net <mailto:Healeys at autox.team.net> 
http://autox.team.net/mailman/listinfo/healeys

Unsubscribe/Manage: http://autox.team.net/mailman/options/healeys/frogeye@porterscustom.com

-- 
Dave Porter Porter Custom Bicycles 2909 Arno St. NE Albuquerque, NM 87107 505-352-1378 <tel:505-352-1378>  Go HERE: my world www.porterbikes.com/ <http://www.porterbikes.com/>  

_______________________________________________
Support Team.Net http://www.team.net/donate.html
Suggested annual donation  $12.75
Archive: http://www.team.net/archive
Forums: http://www.team.net/forums

Healeys at autox.team.net <mailto:Healeys at autox.team.net> 
http://autox.team.net/mailman/listinfo/healeys

Unsubscribe/Manage: http://autox.team.net/mailman/options/healeys/eyera3000@gmail.com

-------------- next part --------------
An HTML attachment was scrubbed...
URL: <http://autox.team.net/pipermail/healeys/attachments/20151230/25dd5fd0/attachment.html>