Dana---MY hat is off to you--what and accomplishment---wmts
>
> From: "Dana" <dana@goulston.net>
> Date: 2003/09/06 Sat PM 06:08:27 CDT
> To: "Land Speed" <land-speed@autox.team.net>
> Subject: Another MegaSquirt lives!
>
> Hi all,
>
> Finally ... the world's first fire-breathing Fuel-Injected GS-Twin lives and
> breaths (yes there were some minor flames as the Ether caught fire --
> woo-yaa!! -- KT-on-my-mind, extinguishers in both hands (draw!) --- bike at
> the open garage door facing outside!!
>
> After a few hours on the phone with Paul B. in VA (referred by a John
> Robinson thank-you-very-much-John!), and shipping the MS unit back and forth
> across the country (user errors in soldering), it finally fired and held
> throttle.
>
> Not an easy deal. Lots of learning curve stuff. I had two wires from the
> throttle position sensor reversed, half a dozen settings in the software set
> wrong, and oh-yes, the best part ... I had the fuel entering the rail outlet
> and exiting the inlet (hey, I never played with EFI before).
>
> For testing, I had a red plastic fuel jug with a hole cut in the top to
> insert the submerged fuel pump (from a 1986 Buick Electra).
>
> I still need to replace my unknown snowmobile injectors with known ones from
> Ford or Chevy, in order to calculate the correct fuel flow. (Anybody know
> where I can get specs on stock injectors for a 1994 Polaris Indy Classic 500
> EFI??)
>
> Next steps:
> clean up the wiring
> replace injectors
> build a tank/seat/tail
> re-wire the fuel pump and f/p relay with a cutoff toggle on the handlebars
> fine tune the software (need to buy a cheapy laptop on eBay) ... it runs
> very rough right now
> find a dyno (haha)
> go to the drag strip to get some numbers
> put more pics on the web-site
> Go Land Speed racing! ... maybe, just maybe I'll make it by the October
> meet.
>
> Onward ... Yippee!
>
> Dana
> 1980 GS-450 (513cc, EFI)
> www.bndracing.com
>
> >
"Sparky"
Lakester 2211
/// unsubscribe/change address requests to majordomo@autox.team.net or try
/// http://www.team.net/mailman/listinfo
/// Archives at http://www.team.net/archive
|